12V低温卷绕电池 汽车启停电池 房车电池 低温储能电池 高倍率大容量低温电池

Spiral Cell Battery 卷绕式蓄电池

 

20世纪80年代以来,美国产螺旋式卷绕蓄电池一直以超级启动电流,强大的抗震能力,以及卓越的高低温性能和超强的循环使用寿命而受到广大专业用户的追逐。 尤其在太阳能户外装置，汽车改装，新能源汽车，航空，工业，船用，及军用市场等领域，其令人信服的质量和性能一直受到业内专业人士和发烧友的追捧。该电池采用的螺旋结构专利为1973年生效,2003年正式年满失效。BLS在国外生产技术专利权解封后就开始自主研发这种高性能蓄电池，自2002年起历时5年深圳宝力晟电池终于在2006年10月成功开发出性能和国外品牌电池相媲美的高性能螺旋卷绕蓄电池。 

The spiral wound technique was originally derived from the U.S. military, for application of armored vehicles, tanks and other military vehicles.In 2004, BLS firstly introduced this new technique ,which breaked the monopoly of other brand battery and can be replaced completely. Meanwhile ,we have gained several patent certificates for this battery technique.By using the alloy with very high hydrogen to form the pallet with a special processing manufacturing grid, stepped by suitable matching process of the positive and negative active material quality, making the negative hydrogen evolution process to be maximumly inhibited. Meanwhile, the excessive oxygen generated by positive over-charge reaches the cathode, make reaction with the lead there ,and result in water. The water is protected from loss and achieves maintenance free of battery.

 

 

   

1.可在-50℃低温正常使用，80度高温电池不鼓胀，不变形。

The battery can be normally used at -50℃, and it won't swell or distort at the high temperature of 80 degree. 

 

 

2.最大30倍的启动电流，是普通电池的3倍。

Its largest starting current is as large as 30 times, which is three times as common batteries.

 

 

 

 

3.启动次数可达15000次,是普通蓄电池的3倍。

 It can be started as much as 15000 times, which is 3 times as common storage batteries.  

 

 

 

4.40分钟内可充入95％以上的电量。

It can charge more than 95% within 40 minutes. 

 

 

 

 

   5.内部无流动液体，可任意方向放置使用。

 There is no flowing liquid inside, so it can be placed at any direction. 

 

 

 

 

6.至少能承受4G(33HZ)震动12小时。

It can bear the vibration of 4G (33HZ) for at least 12 hours.

 

 

 

 

 7.100%深循环放电可达300次，设计寿命长达10年。

100% deep cycling discharge can reach 300 times, and its life can be as long as 10 years. 

 

 

 

 

8.月自放电率仅为3%，放置一年仍能启动车辆。

Its self-discharge rate is only 3% every month, and it can start vehicles when it is placed one year later. 

 

 

 

 

• 50C discharge rate, 3-5 times higher VRLA battery    特殊工艺制造板栅，超长使用寿命

 

BLS系列卷绕电池通过特殊工艺制造板栅，对正负极活性物质量的合理匹配等工艺措施，使得负极上发生的析氢过程得以最大限度地受到抑制，同时正极因过充电所产生的氧气通过隔膜到达负极，并与负极上的铅发生反应，生成水，这样便使得电池内部气体的再复合，防止失水，实现免维护。常温C/5放电倍率下，100%DOD循环寿命350次，浮充使用设计寿命15年。在太阳能领域的设计寿命10年。启动次数可达15000次。

BLS serial battery is fabricated with high pure lead, it has much less side reaction than the normal battery. Current is well Distributed and active material is bigger than surface area with thin plate and special structure. Therefore, BLS can be charged With trickle current, and reach 90% charge efficiency even at cloudy or rainy days。

 

 

• -55 ℃ ~ 80 ℃ working temperature   卓越的低温性能，可在-55℃时正常工作

 

BLS卷绕系列电池引进了特有的低温配方，达到了3倍于普通电池的电极表面积，从而在很大程度降低了内阻，即使在低温下也能正常充放电。高温情况下，板栅腐蚀率通常是非常高的，这时BLS独特的冷轧纯铅板栅却有着比普通铅合金更强的抗腐蚀能力，因此工作寿命也更长。同时，BLS卷绕式电池采用了圆柱形结构和50kap的打开阀门压力，在高温下可避免严重的失水，肿胀或变形，确保其有长时间的工作寿命。

BLS introduced special low temperature active material formula, and achieves 3 folds of electrode surface area than normal Battery, which reduces the internal resistance to a great extent, and then makes itself to be chargeable under low temperature.In case of high temperature, the grid corrosion rate is usually very high, this time BLS’ S cold-rolling pure lead grid has much Higher corrosion resistance capability than normal lead alloy grid, so BLS has much longer working life. At the same time, BLS Can avoid severe water loss, swelling or transformation by cylindrical structure and 50kap open valve pressure under high Temperature, which can ensure its long working life。

 

• No free-electrolyte, can be installed in any position   内部无游离液体，可任意方向放置

 

 

BLS系列纯铅电池使用高度贫液原理制造，电解液量比普通阀控电池还少30%，同时电解液被完全吸附在极板和AGM隔板中，电池内没有游离电解液，因此电池在充电，放电，储存时可任意方向放置而不会出现电解液泄露情况。同时即便是在低温-55℃时，也不会因为内部游离液体结冰而导致电池无法正常充放电。

BLS serial battery adopted much less electrolyte by 30% than normal battery, at the same time, its electrolyte is completely.Absorbed in the plate and AGM separator, which results in that there is no free electrolyte in the battery. So, BLS can be placed t random position without leakage.

 

 

• Fast recharge ability and stable high voltage output    优越的小电流充电接受能力，40分钟可充入95%的电量

 

BLS系列纯铅电池采用99.999%纯铅制作，而且由于极薄的极板和特殊的结构，电流分布均匀，活性物质比表面大。因此可以实现小电流充放电，用做太阳能储备电源时，即使是阴雨天气也能达到90%以上充电效率。BLS系列卷绕电池所采用极板只有0.6-0.9mm厚度，并使用进口专用隔膜，从而电池内阻只有普通蓄电池的1/3，最快40分钟可充入95%的电量。即使在长时间不充电状态下，不需要特殊的充电方式，也能恢复正常容量。

Because BLS has extremely low internal resistance, so it can output high stable voltage under middle and high rate Discharge. In addition, fast charge is possible, 95% plus capability may be charged in 40mins.

 

 

 

• Excellent trickle current charge acceptance.   三倍于普通电池的启动电流

 

BLS系列卷绕电池中采用颠覆传统的板栅加工方式，使得板栅的抗腐蚀性大大加强，从而实现了正板栅的超薄型设计，极板比表面积是普通电池的近3倍，从而保证电池具有其它电池难以匹敌的大电流放电能力。最大可达30倍率瞬间大电流放电，这点在低温下表现的更加明显。

BLS serial battery is fabricated with high pure lead, it has much less side reaction than the normal battery. Current is well Distributed and active material is bigger than surface area with thin plate and special structure. Therefore, BLS can be charged With trickle current, and reach 90% charge efficiency even at cloudy or rainy days.

 

 

• Good ability to work under the PSOC.    超强的抗震动能力

 

卷绕电池an style="padding: 0px; margin: 0px; font-size: 16px;">BLS系列卷绕电池独特的电极结构，每个单体电池均由一片正极与一片负极卷绕而成，电池中电流分布均匀，可靠性高。电池与壳体之前几乎没有空隙，而专用隔板亦能启到很好的缓冲减震作用，故BLS系列卷绕电池至少能承受4G(33HZ)震动12小时以及6G震动4小时。

When a battery is applied in cell system, it can’t be charged 100% after being discharged each time, then the battery begins to work under partial state or charge(PSOC),after a long period, part of active materials will not be utilized, and lose their active capability ,then leads to the failure of the batteries immediately. But BLS’s grid is only 0.6mm~0.9mm in thickness, and with its special separator, its internal resistance is only one third of the normal battery’s, and its capacity can be recovered to the common level after long period shelf without particular charge method.Moreover, it can stand 4G(33HZ) vibration for 12 hours and 6G vibration for 4 hours. 

 

 

 

 

备注：型号不同则价格不同，另需批量采购可电联！联系时请告知是在全球塑胶网看到的！